Kawasaki engine surges at full throttle.

Recently, it started surging and stalling after running for about 30 minutes, whether under load (blades) or not. The automatic choke seems to be the cause as I can see it opening and closing when this happens. I read a few posts on various forums about this issue and have done the following: New spark plugs. new air filter. new fuel filter.Broadcom (AVGO) Surges, Opening the Door to Further Gains...AVGO In my April 13 review of Broadcom (AVGO) I wrote that "AVGO looks like it will rebound from the rising 50-day movin...Tecumseh Engines: With the engine stopped, loosen the screw holding the governor clamp on the governor lever. Rotate the clamp in a direction that will force the throttle shaft open and allow the governor follower arm to rest on the governor spool. Push the governor lever connected to the throttle to the wide open throttle position.John Deere SB-14 with Kawasaki engine. This mower is an oldie but a goodie and I am trying to keep it going. I just had the motor rebuilt last year, but the governer and carb are driving me nuts. It threw the choke spring and I figured out what was wrong, but now the governor seems to be getting stuck as it activates and I guess it must flood ...

Move the throttle to the FAST position. Pull the PTO switch up/out into the ENGAGED (ON) position. NOTE: When operating the tractor be certain that the throttle is always in the FAST position. Operating with the throttle at less than full throttle may lead to premature battery wear and a poor quality cut.

If you are sure a faulty regulator causes the problem, you will need a new one. While you are at it, you can also test the alternator; it could be the cause of the drainage. 6. Fuel leakage. Another repetitive issue is not only one of the Kawasaki fr691v problems but is also found in chainsaws like the Stihl ms 261c-m.what I did to my Kawasaki Mule to hopefully improve the idle and to prevent further dirt and oil goo from entering the throttle body and fouling up the works.

The resulting loss of power will increase the demand for ignition. The Electronic Control Module will overcompensate, leading to engine surging. The fix: This is a problem you can troubleshoot and fix in your garage. Check and replace the distributor cap, rotor, ignition wires, and spark plugs.my dad has a DYS 4500 with a 26 hp Kohler motor PS-SV735-0017. iwas called over to fix and was told it wasnt idling right. The air filter was cloged/ caked with dust. that i thought was the prob. installed new filter and at first wouldnt crank.. then it fired up ran at low idle with no responce in throttle till at mid throttle setting. at full throttle it surges .. is it a …Basically the engine surges or hunts from idle through full throttle. I researched and done all the things that I’ve seen suggested. 3 different carbs. Current one is brand new. Still surges. Fuel pump works. Fuel lines clear. Tested with separate gravity fed fuel supple to carb. Same surge. Adjusted governor. Same surge.I have a John Deere Gator XUV 620i, FD620D CS26 DFI kawasaki engine. At about 130 hours on the machine it has started to run unevenly at low speeds. Mainly at speeds under 10 mph. On a cold start it does not have the problem but as the engine reaches normal operating temperature it starts the low speed uneven rpm problem.2005 club car ds fe290d 9.5 Kawasaki No start Engine turns well Spark on plug (plug out ground to block) Compression 150 psi Was popping back into air cleaner suspected stuck valve 1. ... Engine will barely run with choke full on and ...

I have an LX277, air cooled, Kawasaki FH500V, 494cc, 17HP VTwin OHV. This mower runs a half throttle, but surges when trying to run full throttle. I've changed the fuel lines, fuel pump, solenoid, and cleaned the carb during the past months with no lasting fix. I'm confident this is a fuel/air issue due to the fact that choking the mower will ...

While there are a number of reasons why an engine may suddenly develop a "runs only while the fuel is manually enriched situation", the three most common reasons would be: 1) An air leak has developed around the fuel intake or carburetor areas. and is allowing too much air into the combustion chamber. Inspect the fuel lines for cracks or loose ...

Surging Engine. OK, we have a liquid cooled 27 HP Kawasaki engine model number FD750D-S04. It has a very bad surging problem from half throttle and above as long as it is not under a load. Once the blades are engaged or if you drive up a hill it smooths out and runs great. Another thing is it backfires and sputters when we take it from full ...4 posts · Joined 2018. #1 · Jul 3, 2018. My 1984 JD 240 has a FC420V-DS00 Kawasaki engine that's surging. Its very pronounced at idle, but detectable even at full throttle. Then after running for 30-40 minutes when the engine really heats up, it begins to cut out until eventually the engine will die. If I hold the hood open to increase air ...I have a Briggs 10hp model 28b707 with a Walbro 5-4993 LMT carburetor on a Snapper 5R1026 riding mower. The engine constantly surges or hunts except on full throttle. If I partially close the choke th … read moreSo I have the engine in and running. It runs well on full throttle and with the blades and drive going, but at low speed it surges and hunts. I accidentally read the tappet clearance wrong from the manual and ground way too much off the valve stems .040 instead of .004. Would this cause the surging?New-to-me mower (Cub Cadet Commercial Tank) with a 23 hp Kawasaki FH680V-BS18, 270 hours I had a hot start problem, repaired a chafed stator wire, disassembled & cleaned the carb & installed new gaskets, and set the valve lash to 0.004. The hot start problem went away, but now... At idle, it searches/surges around the set 3600 rpm idle speedI have a Briggs 10hp model 28b707 with a Walbro 5-4993 LMT carburetor on a Snapper 5R1026 riding mower. The engine constantly surges or hunts except on full throttle. If I partially close the choke th … read more3 posts · Joined 2006. #1 · May 29, 2007. I have a 34Z Gravely with a 15 hp Kawasaki and this is whats happening. When we start it up when it is cold it runs fine. After it warms up it starts to miss on one cylinder. I changed the coil but it didn't seem to help. Has anyone ever encountered this. Your help would be greatly appreciated.

The flywheel has fan blades on it that move air across the engine for cooling. The governor has a small air vane next to the flywheel that changes position based on how much air passes it. It's linked to the throttle by a spring: once the engine is up to speed, the air pushes on the vane and it pulls on the spring, closing the throttle.Reason 1: High Float Level. Your Predator 212 will sputter at full throttle if your float level is high. The fuel level in the carburetor bowl is controlled by the float level. Sputtering can occur when the carburetor is flooded at full throttle by a high float level. Furthermore, if the float has a hole, it sinks and doesn't regulate the ...A clogged or dirty air filter can restrict airflow, leading to an unbalanced mix that bogs down the engine. Regularly inspect and clean your air filter or replace it with an air kit to ensure optimal air intake and engine performance. Contaminated Carburetor: Another common issue that can lead to bogging during acceleration is a dirty carburetor.Member. Hello everyone I have been working on a project for some time that is a predator 212 swapped yamaha yl2. The bike is a joy to ride but it has had lots of reliability issues over the 6 months ive been riding it. The first issue I encountered was with the engine completely stock. When I would start getting on the throttle it would perform ...Is your riding mower engine surging mostly UNDER LOAD at MID RANGE THROTTLE / RPM? Check this somewhat hidden and fragile carburetor linkage spring first bef...9. Messages. 63. Aug 2, 2019 / Gravely losing power under load. #4. Oh and see if your carb has an adjustment knob. Some do some dont. Also make sure there isnt debris in gas tank limiting the amount of fuel being pulled through. Make sure there is no vacuum leak on engine side of carb.

I have an LX277, air cooled, Kawasaki FH500V, 494cc, 17HP VTwin OHV. This mower runs a half throttle, but surges when trying to run full throttle. I've changed the fuel lines, fuel pump, solenoid, and cleaned the carb during the past months with no lasting fix. I'm confident this is a fuel/air issue due to the fact that choking the mower will ...

Locate the limiting mechanism by lifting up the cargo bay at the back, finding the black metal cover which is riveted over the governor (has the throttle rod going underneath it from the carburettor), drilling out the three rivets and removing the metal cover. Find the parts that resemble this:Kawasaki FX1000V EFI problems. Hello all, just bought myself a brand new Spartan SRT-XD with the above mentioned engine, 38.5 hp. First half hour of the day went great, wasn’t mowing anything too crazy, then started having engine issues. Every 15-25 minutes the engine would lose RPM’s and nearly die, backfire, and then resume normal …Sep 30, 2003 · Short of choking the machine in tall grass or an old machine with worn block, surging is symptomatic of improper and varying ratios of the fuel/air mixtures. The four most common I have found are: The governor spring is broken or in the incorrect adjustment hole. The small spring that takes the play out of the throttle linkage is either broken ... Yeah the LX178/188 had their fair share of engine fires. There is an upgraded fuel pump to address the issue. Gas from the carb sounds like the float is sticking or like you said dirt on the needle valve. Bad news on these carbs is the seat is not replaceable so if you can't fix it by cleaning you have to buy a new carb.I have an LX277, air cooled, Kawasaki FH500V, 494cc, 17HP VTwin OHV. This mower runs a half throttle, but surges when trying to run full throttle. I've changed the fuel lines, fuel pump, solenoid, and cleaned the carb during the past months with no lasting fix. I'm confident this is a fuel/air issue due to the fact that choking the mower will ...Messages. 341. Aug 20, 2018 / FR730V Carb Whistling/Surging. #2. Surging is always caused by a lean condition as evidenced by applying choke (enriching the fuel/air mix). Could be from debris in carb (something you missed) or a leaking gasket (the whistling you hear) or possibly just an EPA issue. S.10-21-2006, 02:11 PM. Re: STX 1100 DI Engine Revs Surging. Guy. Thanks for the feedback, yes the problem does come in when warm and is speed dependant however is not a misfire or lumpy running. If increase the throttle from say 50 to 75 to 100 % then speed builds and then it surges and slows back to 50% to 75%, the surging is just as though I ...5. Nov 24, 2014 / John Deere D110 Surges at all throttle positions. #1. I have a JD D110 and the motor surges up and down through all throttle positions. I can see the governor rod moving back and forth. The mower only has 80 hours on it. I have done all the required mtc on the mower so far.5 posts · Joined 2010. #1 · Apr 4, 2013. I have a 2007 exmark turf tracer hp with a 17 hp kawasaki motor. Has maybe 400 hours. Engine has been surging from idle to nearly full throttle. Doesn't surge at wot but engine doesn't sound smooth. I have done research and tried all the secrets and tricks on here. I've had the carburetor off 8 times ...since you are only getting a surge during full throttle and no codes, have you tried cleaning out the injector body throat? Pull the injector and clean it with ...

I have a 2007 3010 gas Mule. Problems include: 1) when engine is running and in gear the machine will go very slow( wether in slow or fast or 2 vs 4 wheel). ... push throttle lever full forward, then 4) move left hand to wrench to pinch the clamp. After performing the above, and with the governor spring reattached, verify that at full open ...

New member. Apr 28, 2016. #1. have a 1990 evinrude tracker 30hp that runs fine at idle. take it to the lake and it runs fine in no wake zones. whenever the motor is cold the boat will run fine at full throttle. whenever it runs for 10 minutes and the motor gets hot it will start surging like a cylinder is missing. thought i was getting fuel in ...

Apr 4, 2013 · 5 posts · Joined 2010. #1 · Apr 4, 2013. I have a 2007 exmark turf tracer hp with a 17 hp kawasaki motor. Has maybe 400 hours. Engine has been surging from idle to nearly full throttle. Doesn't surge at wot but engine doesn't sound smooth. I have done research and tried all the secrets and tricks on here. I've had the carburetor off 8 times ... Aug 21, 2017 / FR691V 24 HP surges and dies under load and or when hot. #2. Something most folks never consider is the fuel hose has braided nylon string in the middle of the hose. The hose can feel strong, not soft spots anywhere on it's entire length. However, a fuel hose can have a small spot anywhere on the inside that turned loose …The Mule is now having trouble idling and it will sometimes quit running. It surges at idle and seems to be running rough. I can't figure out what it is. A new fuel pump is very expensive ~$500. Injectors are $100 each as well. I checked the gas tank vent lines (OK). I checked the air filters and intakes (OK).Received 35 Upvotes on 34 Posts. The surging business is usually a lean mixture. It can be caused by a vacuum leak from carb to manifold to cylinder, or low fuel available to the carburetor, or leaking crank seals. If the saw is running well except at full throttle, it's probably in the fuel available to the carb (ie lines, filter, tank cap ...Unintended acceleration may mean that a car’s throttle is stuck in an open position or that there is a problem with the gas pedal. Mistakes also lead drivers to believe their cars ...5. Aug 6, 2018 / Dreaded John Deere SURGING. #9. bertsmobile1 said: Mowers have not been idled down before shut off for decades it actually increases the heat in the engine. If it only surges at idle then the idle fuel circuit in the carb is still blocked. They can be a bugger to clean and some times they can not.The problem showed itself at first like a slight "miss" occasionally when pulling a load, and eventually, over a couple months, it led to "surging" at idle and complete failure while cutting 5" high grass after only a couple of feet. The sputtering seemed to only occur after the engine warmed up (about an hour of cutting) at first but over the ...28021 posts · Joined 2011. #3 · May 12, 2014. You have dirt in the low speed circuit of the carb. The mower is running good under load because it is drawing fuel from the high speed jet in the carb, but once you remove the load and try to run at idle, the small blockage in the idle circuit is not allowing enough fuel past, and it surges.Jun 6, 2013 · kbeechler. 11 posts · Joined 2022. #9 · Nov 8, 2022. I’m reading about the Kawasaki FJ180V surge, I have a brand new machine, straight out the box, it too surges during load, it idles beautifully.. it will really surge at full throttle, but if I back it off to about 3/4, it surges very little.. While there are a number of reasons why an engine may suddenly develop a "runs only while the fuel is manually enriched situation", the three most common reasons would be: 1) An air leak has developed around the fuel intake or carburetor areas. and is allowing too much air into the combustion chamber. Inspect the fuel lines for cracks or loose ...19 hp kawasaki engine experiences loss of power under load. Yesterday I cleaned the carb. All simple, regular maintenance on it (spark plugs, oil, etc.) has been taken care of. ... I have a surging kawasaki FR651V 22 hp twin. New fuel filter, air filter, plugs, clean gas, oil filter and oil. ... Shoes do better at full throttle but seems to be ...

if your Kawasaki lawn mower engine throttle is all the way down and still idling too high this is how you can adjust it to where it'll idle lower.After doing...You can try the old school trick of running the engine at full revs and closing the choke until it almost dies. Open the choke and let the engine stabilize. Repeat this process a few times. You might get some good results. If not, the only true way to effect repairs is to disassemble the carb and fully clean it.aroddy. 451 posts · Joined 2011. #6 · Oct 20, 2018. If one plug was fouled or wet vs the other. Pull the valve cover on that side and make sure you don't have a bent pushrod or the bolt that holds the valve rocker hasn't back off / broke. We see it all the time. DXN1EL, Ridin' Green, sjessen and 1 other person.Instagram:https://instagram. wrigley section 131nau fall semester 2023ed herman net wortheat n park 20 off coupon 2023 I'm out of ideas! It just doesn't make sense. I start it, it idles ok, I can apply throttle and rev the engine just fine for the first couple of minutes, and then, after that, it wants to die if I touch the throttle. It seems to be consistent; whenever the engine is cold, it runs fine for a couple of minutes.185 posts · Joined 2001. #1 · Jul 5, 2001. i have a hustler z and love it so far! one problem i have is the kawasaki 23hp engine started surging at about 40 hours. The local dealer cleaned and eventually replaced the carb. problem was fixed, or so I thought. Now I have to engauge blades at full throttle or the engine will die. golden one coin machinegalaxy skin swapper v2 The engine will often run fine at idle, but will die when it is throttled up. This is because there is less air moving through the engine at idle. When the engine is run at full throttle, especially under load, the air flow is much greater, which causes more back pressure, and results in the engine stalling. steve torre sirius cub Z-Force S surging and dies at idle. My 2012 Cub Cadet Z-force-S 48 with Kawasaki engine has always started with very little choke, run well at high speed, did not slow down much when throttled down to idle, and seemed to run rich since I bought it with 167 hours in 2016. Last week while mowing it started to surge and spit at high speed and ...Kawasaki V2 engine problems. I have a Husqvarna AWD ride on with a Kawasaki FH531V 18.0 engine, done 520 hours. Motor started running rough about 2 months ago, was fine at full throttle under load but rough at idle and half throttle. I changed spark plugs, cleaned air filter, cleaned fuel filter but problem continued.